Find by category:

Exhaust Notes

1.37 million Honda, Toyota and Ford vehicles investigated for defects

NHTSA probes could lead to recalls; two of the inquiries have been ongoing since last October.

By Exhaust Notes Feb 25, 2013 11:54AM

The National Highway Traffic Safety Administration is looking into problems that could affect more than 1.37 million vehicles made by Honda, Toyota and Ford.

NHTSA runs several dozen defect investigations at any given time, all stemming from public complaints and petitions. A recall can be issued if the agency deems there is sufficient evidence of a widespread problem, although this does not always happen.


On Thursday, the agency updated its investigation reports regarding the three automakers.

About 724,982 Ford Escape and Fusion models from the 2009 to 2011 model years are under investigation for failing electronic throttle bodies that could cause the vehicles to stall or surge unexpectedly. The sister Mercury Mariner and Milan models are also included. The investigation follows an October petition that urged NHTSA to investigate 1.6 million Escape SUVs from the 2005 to 2012 model years for the same alleged problem.

In total, NHTSA and Ford have found 1,448 instances relating to the throttle body, which controls vehicle acceleration. Faults with the throttle body caused many of the vehicles to resort to a "limp home" mode, which restricts vehicle speed and engine revs to protect failed components from damaging the powertrain.

The various "limp home" modes can cause the vehicle to surge or appear to stall, even though the engine is still running, the report said. Ford said it had 27,505 warranty claims relating to repair or replacement of the throttle bodies.

The agency has also received requests to investigate the 2001-2004 Escape and the 2000-2003 Ford Taurus and Mercury Sable models for alleged stuck throttles, although no action has been taken.

The 2004-2009 Toyota Prius is being investigated for excess wear on a coupling joint of the steering shaft. About 561,000 vehicles may be affected, although the investigation is based on one complaint and the defect may have been resolved through an earlier recall.

In November, Toyota recalled 670,000 second-generation Prius models from 2004-2009 that had intermediate extension shafts that were of "insufficient strength" and could snap. The shafts connect the steering wheel near its gear box inside the cabin. Toyota said that the shaft could break if drivers turn the steering wheel to its full left or right positions at low speeds, such as when parking, or if a tire were to hit a curb at low speeds.

In June 2011, Toyota recalled 52,000 models of the first-generation Prius to fix a power steering problem that could make the car difficult to turn.

NHTSA engineers are looking into the 2005 Honda Pilot for unexpected emergency braking and stability control intervention on as many as 87,803 vehicles. The agency has recorded 185 instances of Pilots applying the brake assist function, which automatically applies full braking force when the pedal sensors detect a panic stop, without reason.

Some owners alleged that the car applied the brakes without the pedal being pressed. Twenty complaints allege the Pilot's stability control system intervened without reason, which caused the vehicle steering to pull by application of individual brakes.

Honda has identified problems with the yaw sensors and algorithms used to determine if the vehicle is in a slide or other emergency situation.

[Source: NHTSA]

Feb 25, 2013 3:30PM
I bought my ex wife a Pinto wagon with Firestone 500's and I haven't heard from her since.
Feb 25, 2013 2:22PM
none of my 7 cars are on the list. my newest car is a 67n impala.aint no eletronic crap on none of my cars. they all can be fixed with out a 10,000 dollar computer to tell you a whats daily driver is a original galaxie 500 with a 352cid that old girl everywhere...
Feb 25, 2013 5:26PM
Im a technician working on Ford and GM vehicles everyday. ALL of the parts that I replace on the GM vehicles are made in China now! ALL of them. I am talking AC Delco and GM parts, not aftermarket! Parts that were made in Mexico, Indonisia and here are made in China! So explain to me how us as americans are benefiting from bailing out GM!!!
Feb 25, 2013 2:50PM
Just replaced throttle body on a 2007 Chevy HHR today after a couple of months of ongoing "limp home" or in GM jargon "engine power reduced" problems, and heard from the service person that the same manufacturer was producing these parts for GM, Ford and Chrysler and they have all had problems. Definitely sounds like a recall is needed, maybe I could get my $425 back from today, that would sure be nice
Feb 25, 2013 1:57PM

and people complain about the problem Boeing is having?

Feb 25, 2013 1:52PM
Feb 25, 2013 2:14PM
Just happened to my GMC Denali....had to "limp home" doing 20mph.  The fix, had to get new throttle body.  This is happening on all cars....where is the recall!!!!!
Feb 25, 2013 3:16PM
Glad to know my Grandsons Tonka trucks are safe. Whew!
Feb 25, 2013 1:54PM
To quote your article, "NHTSA runs several dozen defect investigations at any given time,"  You need a story so you mention 3 of them??  Lame.
Feb 25, 2013 1:40PM
Please help us to maintain a healthy and vibrant community by reporting any illegal or inappropriate behavior. If you believe a message violates theCode of Conductplease use this form to notify the moderators. They will investigate your report and take appropriate action. If necessary, they report all illegal activity to the proper authorities.
100 character limit
Are you sure you want to delete this comment?
MSN Money


Cars are cool, and here at MSN Autos we love everything about them, but we also know they're more than simply speed and style: a car is an essential tool, a much-needed accessory to help you get through your day-to-day life. What you drive is also one of the most important investments you can make, so we'll help you navigate your way through the car buying and ownership experiences. We strive to be your daily destination for news, notes, tips and tricks from across the automotive world. So whether it's through original content from our world-class journalists or the latest buzz from the far corners of the Web, Exhaust Notes helps you make sense of your automotive world.

Have a story idea? Tip us off at